Flocculating Agents

Boiler Water Treatment Chemicals Concentrated liquid alkaline product for corrosion and Calcium scale control in boilers. Very usefull Concentrated Alkaline Liquid For Maintaining Ph - To adjust alkalinity.

Suitable for Low-pressure boiler systems (0-32 bar) , medium-pressure steam propulsion vessels (32-60 bar). And also suitable to used for high pressure steam generating systems (60-84 bar).

Mechanism : It converts calcium hardness into soft, non-adherent sludge that is easily removed by blowdown.

Water Filter, Vessel, Softner, Accessory-32

Flocculating Agents

Alkalinity Builder Very usefull Concentrated Alkaline Liquid For Maintaining Ph which protects corrosion, scalling by controlling Calcium scale in water system.

Application

RXSOL-50-5002-025 provides the alkaline condition for hardness control to function correctly. Without the correct precipitation and subsequent blow down of hardness salt, scale would form. This would result in restriction in water flow, ineffective heat transfer and local corrosion. The end effect would be an inefficient boiler and ultimately component failure. RXSOL-50-5002-025 also provides the alkaline condition required for corrosion control, by neutralization of acidic gases

Dosage

For optimum results dose RXSOL-50-5002-025 direct to the boiler with a RXSOL Boiler Water Treatment Dosing unit, or via the bypass pot- feeder installed in the boiler feed line. Required dosage can be controlled by pH & alkalinity test dosage chart . 1 milliliter of RXSOL-50-5002-025 concentrated alkaline liquid per ton of distilled water provides 0.5 ppm of lkalinity hydrate. Low-pressure boiler (up to 28 bars) Add RXSOL-50-002-025 to 5 litre in feed – water, There is no any specific method can be passed through the recalculating or the main feed pipe into the stream or the hot well tank. High – Pressure Boiler (28 to 60 bars) Dissolve the desired volume of RXSOL-50-002-025 to 5 ltr of feed – water, which should then be passed into the stream or water drum through the chemical pump. Note:- It can also be used as a neutralizing agent following acid cleaning with descaling materials ( RXSOL-11-1008--DC descaling Liq / RXSOL-54-1008-SA Safe Acid PWD )

Technical Specification

Testing control procedure

Test water sample from the water boiler as described in the direction of the Alkalinity Test Kit ( p & m Total ) http://www.rxmarine.com/Alkalinity-test-kit
Determine the present alkalinity value expressed as ppm CaCO₃ .
Desired level of 100-150 ppm as CaCO₃.
A control test for the alkalinity of the water should be conducted after 3- 6 hours from the application.

MSDS

Product Name	:	RXSOL-50-5002-025
Product Type	:	ALKALINITY CONTROL 25 Ltr

Company Details:

RX MARINE INTERNATIONAL
105, A wing , BSEL , TECH PARK.
VASHI ,NEW BOMBAY 400703 INDIA

Stock Point : Mumbai, Kandla, Surat, Kolkata, Chennai, Visakhapatnam, Fujairah, Muscat

Phone	:	+91 22 27815541 / 42
Fax	:	+91 22 2781 1318 :::AOH :0091 9821214367
Email	:	mail@rxmarine.com

Chemical Name	Concentration	CAS Number	EC Number	R Phrases*	Symbols
Metalic hydroxide which includes Sodium Hydroxide	27 - 36	1310-73-2	215-185-5	35	C
Non classified ingredients Proprietory Blend of Polymer	64-73	These products are not classified as hazardous and lower then hazard limits	NA	NA	NA

*See Section 16

corrosive

Corrosive

Odour	Odourless.
Appearance	Liquid, colourless to yellow, soluble in water.
Contact with eyes	Corrosive to eyes Can cause damage to the eyes.
Contact with skin	Causes severe burns (R35).
Inhalation	No information available but must be considered harmful.
Ingestion	Harmful if swallowed (R22).

Contact with skin	Remove contaminated clothing immediately and drench affected skin with plenty of water Then wash with soap and water.Seek medical advice if necessary
Contact with eyes	If the substance has got into eyes, immediately wash out with plenty of water for at least 15 minutes. Irrigate eyes thoroughly whilst lifting eyelids.Obtain immediate medical attention. Continue flushing with water until medical help arrives
Ingestion	Do not induce vomiting.Never give anything by mouth to an unconscious person.Give water or milk to drink.Obtain immediate medical attention.
General	In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible) (S45) -When in doubt or symptoms persist, seek medical attention

-   Non-combustible
-   Smoke from fires is corrosive
-   Not flammable. In case of fire use extinguishing media appropriate to surrounding conditions
-   Vapour density - not applicable

Personal Precautions	Wear protective clothing as per section 8.
Environmental Precautions	Do not flush spilt material into any public water system.
Clean Up Actions	Absorb spillage in inert material and shovel up.Ventilate the area and wash spill site after material pickup is complete.Neutralise with Acid.
Special Precautions	Wear protective clothing as per section 8.

Handling	Eyewash bottles should be available.See Section 8
Storage	Keep only in the original container in a cool, well-ventilated place (S3/9/49).Protect from frost.

Exposure Limits	OES / LTEL # ppm 2 mg/m3.(Sodium hydroxide)
Exposure controls	No special ventilation is required unless the product is used in a spray form
Occupational exposure controls	Wear suitable protective clothing, including eye/face protection and gloves (plastic or rubber are recommended).During fumigation/spraying wear suitable respiratory equipment (S42)

gloves suit goggles no_smoking

Gloves Suit Goggles No_Smoking

Odour	Odourless
Appearance	Liquid, colourless to yellow, soluble in water
PH	11.5 - 12.5 at 0.1 % concentration , Neat : 14.0
Boiling point	100 °C at 760 mm /Hg
Vapour pressure	Not known
Vapour density	Not applicable
Freezing point	0 °C at 760 mm/Hg
Completely soluble in water
Specific gravity	(water=1) 1.50
Non-combustible

-   This article is considered stable under normal conditions
-   Avoid overheating, Keep away from frost
-   Incompatible with acid
-   See Section 5

Toxicological information	The ingestion of significant quantities may cause burning sensation.Can cause damage to the digestive system.
Inhalation	Not regarded as a potential route of exposure. Can cause damage to the respiratory system.
Contact with skin	Causes severe burns (R35)
Contact with eyes	Causes severe burns (R35)
Ingestion	The ingestion of significant quantities may cause damage to the digestive system.
Carcinogenicity	No evidence of carcinogenic effects.

Ecotoxicity	May cause acute effects in the aquatic environment.
Mobility	Completely soluble in water.
Persistence and Biodegradability	Degrades by hydrolysis
Bioaccumulation Potential	Bioaccumulation is insignificant
Other Adverse Effects	No environmental problems are expected when the product is used/handled correctly. In its intended use, the product will not be released into the environment.

Classification	This material and/or its container must be disposed of as hazardous waste.EU Waste class: 06 02 02
Disposal considerations	Do not discharge into drains or the environment, dispose to an authorised waste collection point.Disposal should be in accordance with local, state or national legislation

Proper Shipping Name:
UN
	Proper Shipping Name	Sodium hydroxide. solution
	UN NO.	1824
	Hazard Class	8	Packing Group	II
Road/Rail (ADR/RID)
	Proper Shipping Name	Sodium hydroxide. solution
	ADR UN No.	1824
	ADR Hazard Class	8	Termcard	80S1824
Sear (IMDG)
	Proper Shipping Name	Sodium hydroxide. solution
	IMDG UN No.	1824
	IMDG Hazard Class	8	IMDG Pack Group	II
	IMDG EmS	F-A, S-B	IMDG subrisk	NA
Air(ICAO/IATA)
	ProperShippingName:	Sodiumhydroxide, solution
	ICAO UnNo.:	1824
	ICAO HazardClass.:	8	ICAO PackingGroup.:	II
	ICAO subrisk:	N/A	ICAO Labels	8, CAO
	ICAO Flashpoint:	N/A
DOT/CFR(USDepartment ofTransportation
	DOTProperShippingName:	Sodium hydroxide, solution
	hazardous material	Sodium hydroxide
	Hazard Class:	8	IdentificationNumber:	UN1824
	Product RQ (lbs):	3640	DOTsubrisk:	N/A
	DOTLabels:	8	DOTFlashpoint:	N/A

Risk Phrases	Causes severe burns (R35)
Safety Phrases	In case of contact with eyes, rinse immediately with plenty of water and seek medical advice (S26).Wear suitable protective clothing, eye/face protection (S36/39).In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible) (S45)

The text of R and S phrase codes used in this safety data sheet:- R35: Causes severe burns.The information provided about the product on this Safety Data Sheet has been compiled from knowledge of the individual constituents The data given here is based on current knowledge and experience. This Safety Data Sheet describes the product in terms of safety requirements and does not signify any warranty with regard to the product's properties.The data given here only applies when product used for proper application(s). The product is not sold as suitable for other applications - usage in such may cause risks not mentioned in this sheet. Do not use for other application(s) without seeking advice from manufacture This Safety Data Sheet is provided in compliance with The Dangerous Substances Directive (67/548/EEC) This Safety Data Sheet is provided in compliance with The Dangerous Preparations Directive (88/379/EEC) This Safety Data Sheet is provided in compliance with The Safety Data Sheets Directive (2001/58EC)

DISCLAIMER OF LIABILITY :The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable.

Enquire About This Product